- Research article
- Open Access
The antimicrobial effect of Octenidine-dihydrochloride coated polymer tracheotomy tubes on Staphylococcus aureus and Pseudomonas aeruginosa colonisation
BMC Microbiology volume 9, Article number: 150 (2009)
The surface of polymeric tracheotomy tubes is a favourable environment for biofilm formation and therefore represents a potential risk factor for the development of pneumonia after tracheotomy. The aim of this in-vitro study was to develop octenidine-dihydrochloride (OCT) coated polymer tracheotomy tubes and investigate any effects on Staphylococcus (S.) aureus and Pseudomonas (P.) aeruginosa colonization. Additionally the resistance of the OCT coating was tested using reprocessing procedures like brushing, rinsing and disinfection with glutaraldehyde
Contamination with S. aureus: Before any reprocessing, OCT coated tracheotomy tubes were colonized with 103 cfu/ml and uncoated tracheotomy tubes with 105 cfu/ml (P = 0.045). After reprocessing, no differences in bacterial concentration between modified and conventional tubes were observed.
Contamination with P. aeruginosa: Before reprocessing, OCT coated tubes were colonized with 106 cfu/ml and uncoated tubes with 107 cfu/ml (P = 0.006). After reprocessing, no significant differences were observed.
OCT coating initially inhibits S. aureus and P. aeruginosa colonisation on tracheotomy tubes. This effect, however, vanishes quickly after reprocessing of the tubes due to poor adhesive properties of the antimicrobial compound. Despite the known antimicrobial effect of OCT, its use for antimicrobial coating of tracheotomy tubes is limited unless methods are developed to allow sustained attachment to the tube.
In comprehensive studies examining the aetiology of ventilator-associated pneumonia (VAP), Staphylococcus (S.) aureus and Pseudomonas (P.) aeruginosa have been found to be the most frequently isolated gram positive and gram negative organisms, respectively . Nosocomial pneumonia in intensive care units (ICU) caused by S. aureus has increased steadily over the past two decades . After only a few days of mechanical ventilation, the cuffed polymer endotracheal tube is coated with a thick bacterial biofilm which has to be regarded as a continuous source of bacterial colonization of the lower respiratory tract ultimately resulting in VAP . Treatment of infections associated with medical devices is often frustrated by the inability of antibiotics to penetrate biofilms and the increasing resistance of microbes to antibiotics . In unpublished studies, we have identified bacterial colonization of 106 colony forming units (cfu)/ml on cuffed tracheotomy tubes after 3 days of use.
Silver tracheotomy tubes with inherent antimicrobial properties previously used in patients with a permanent tracheostomy have been replaced with polymer tracheotomy tubes which have improved patient comfort. With the increasing use of un-cuffed polymer tracheotomy tubes, monitoring of biofilm formation has become important and regular reprocessing of the un-cuffed tracheotomy tube 1 to 2 times a day is usually recommended by the manufacturer in order to avoid infections.
In order to lengthen medical device usage and to improve patient safety with higher quality polymer tracheotomy tubes, coating with an antimicrobial agent has been suggested . Octenidine-dihydrochloride (OCT) could represent a candidate compound since it has a broad-spectrum antimicrobial activity and low toxicity. Studies on resident skin flora have demonstrated the bactericidal and fungicidal efficiency of OCT .
The aim of this study was therefore to develop an OCT coated tracheotomy tube in cooperation with the Heimomed Company and to investigate the antimicrobial inhibitory effect of coated OCT on experimental biofilms formed by S. aureus and P. aeruginosa in-vitro. The OCT coating was then tested for resistance to the tube reprocessing procedures of brushing, rinsing and disinfection with glutaraldehyde.
Significant differences in bacterial contamination were observed between uncoated and OCT coated tracheotomy tubes (see "Additional file 1").
Contamination with S. aureus
Contamination with S. aureus showed the mean concentration of 103 cfu/ml on OCT coated tracheotomy tubes (group A) was significantly lower compared to uncoated tubes (105 cfu/ml; group B; P = 0.045). After five rounds of chemical reprocessing, a hundred fold difference between the colonization of both tube groups (group A = 104 cfu/ml; group B = 106 cfu/ml; P = 0.011) was observed. Following five further procedures of chemical and mechanical reprocessing, recontamination with S. aureus led to the similar colonization of both tube types (per Group: A+B = 106 cfu/ml; P = 0.115). These results are illustrated graphically in Figure 1.
Contamination with P. aeruginosa
Prior to reprocessing, significant differences were seen between the mean concentration of P. aeruginosa colonization on OCT coated tracheotomy tubes (group C) of 106 cfu/ml and uncoated tracheotomy tubes (group D) of 107 cfu/ml (P = 0.006). After reprocessing, no statistical differences were observed (per group: C+D = 107cfu/ml), P = 0.184 (Figure 2).
The goal of this study was to design an OCT coated polymer tracheotomy tube and to investigate antimicrobial inhibitory effects of the coating on S. aureus and P. aeruginosa colonization in vitro.
In current clinical practice, the use of polymer tracheotomy tubes leads to the early development of a thick biofilm followed by colonization of the lower respiratory tract as a potential risk factor for VAP, especially on cuffed tubes which are used for ventilation in ICU patients. Biofilm development starts after 6 hours and becomes abundant after 96 hours . Different antiseptic agents embedded in or coated on polymer tracheotomy tubes have been proposed as an approach to reduce the bacterial burden and lower the risk of VAP development . In this study, together with the manufacturer we developed OCT coated polymer tracheotomy tubes and investigated them in an experimental in vitro setting. The chemical, antimicrobial and toxicological properties of the bispyridine OCT has been described previously [9, 10]. OCT is a potential non-alcoholic mucous skin and wound antiseptic, which destroys bacterial cells by interacting with their cell wall and intracellular components. Even at low concentrations (0.1% and below), OCT is considered bactericidal and fungicidal. In this study, a thousand-fold reduction in S. aureus colonization before reprocessing was achieved by OCT coating of the polymer tracheotomy surface. Although this result shows a favourable reduction required for antimicrobial medical devices , this activity vanished rapidly after tube reprocessing. Colonization of P. aeruginosa was inhibited less by the OCT coating than S aureus even before any reprocessing. In cuffed, single use tracheotomy tubes at the ICU, OCT coating might be of significant benefit because of the reduced S. aureus and P. aeruginosa bacterial burden. However, in the long-term use of un-cuffed polymer tracheotomy tubes, a benefit for the patient would not be expected due to the insufficient antimicrobial effects after daily reprocessing procedures as suggested by the manufacturer. These results are in contrast to recent studies that reported a sufficient reduction of P. aeruginosa on skin and dental plaques after application of OCT [12, 13]. It is possible that the low concentrations of the OCT coating and poor adhesion to the tracheotomy tube polymer surface may explain the low antimicrobial effect. Superficial adhesion is thought to be rapidly eliminated by brushing and chemical reprocessing procedures. An alternative antimicrobial strategy might be to silver coat tracheostomy tubes which could prevent bacterial colonization more reliably and efficiently . Although silver coating might be of clinical interest in the future, up to now its impact on VAP incidence has not been investigated thoroughly.
The results of this study have some limitations. We did not demonstrate the actual presence or examine the nature of the developed biofilms such as by using scanning electron microscopy of the colonized tracheotomy tubes in the presence or absence of OCT. However, the methods utilized are able to detect the presence or absence of bacterial colonisation even after a short time of 24 hours, which represents the initial step in any biofilm formation. Moreover, there is no marker suggesting a change in the pathogen metabolism after 24 hours. A study in vivo would be required to strengthen our results and some animal models suitable for investigation of tracheotomy tubes exist. However, in view of the discouraging results in vitro, we did not pursue further testing in vivo as we believe that based on our data, animal tests would be ethically unjustifiable. Finally, although VAP is associated with specific pathogens, bacterial biofilms have been described to be polymicrobic and the overall composition may greatly influence the bio-burden and infectious nature of the biofilm.
In summary, OCT coating of tracheotomy tubes shows an antimicrobial effect and reduces colonization and biofilm formation on polymer tracheotomy tube surfaces. This effect diminishes quickly after reprocessing of the tubes. Therefore, despite the known antimicrobial effects, the use of OCT for antimicrobial coating of tracheotomy tubes seems to be ineffective in the absence of methods that allow sustained attachment of the antimicrobial compound to the tube.
In order to prevent or delay formation of biofilms, a new polymer tracheotomy tube coated with OCT was designed in cooperation with Heimomed (Kerpen, Germany). The manufacturer coated its commercially available tracheotomy tubes with an adherent solution of OCT. These OCT coated tubes are currently not certified for in vivo use in patients and were prepared only for this study. For tracheotomy tube contamination, standardized test organisms of S. aureus (ATCC 6538) and P. aeruginosa (ATCC 9027) were used. For each pathogen, colonization on four tracheotomy tubes coated with OCT and four conventionally tracheotomy tubes was compared.
A suspension of 0.9% saline solution, 1% mucin and albumen imitated the adhesive properties of tracheal and bronchial mucous. An average of 106 cfu/ml was ascertained in this solution using a densitometer.
The suspension was filled into the inner lumina of all tubes. Excess fluid was removed after one hour of contamination at room temperature and the fully sealed tubes incubated for 24 h at 37°C. Segments (5 mm) were then excised from each tube and vortexed for 30 s in a neutralizing solution containing 5 ml of 0.9% saline and a combination of 3% saponin, 3% tween 80, 0.1% histidine and 0.1% cysteine for OCT inactivation. A series of 10-fold dilutions were made from each sample fluid and pipetted onto Mueller-Hinton/McConkey agar. Each dilution step was repeated in triplicate. After incubation at 37°C for 24 hours, the numbers of colonies were counted and analysed.
S. aureus contaminated tubes were cleaned chemically with glutaraldehyde (2%) 5 times each and then re-contaminated. Manual brushing was added for the second reprocessing procedure. P. aeruginosa contaminated tubes were reprocessed mechanically and chemically 5 times between contamination procedures (Table 1).
The number of pathogens was calculated as mean cfu ± standard deviation (SD) and presented in groups. The experiments were repeated in quadruplicate for 24 hours. A one-sided t-test was used to determine statistical significant differences. A p-value of < 0.05 was considered statistically significant.
Gonzalez C, Rubio M, Romero-Vivas J, Gonzales M, Picazo JJ: Bacteremic pneumonia due to Staphylococcus aureus: a comparison of disease caused by methicillin-resistant and methicillin-susceptible organisms. Int J Infect Dis. 1999, 29: 1171-1177.
Rello J, Diaz E: Pneumonia in the intensive care unit. Crit Care Med. 2003, 31: 2544-2551. 10.1097/01.CCM.0000089928.84326.D2.
Adair CG, Gorman SP, Feron BM, Byers LM, Jones DS, Goldsmith CE, Moore JE, Kerr JR, Curran MD, Hogg G, Webb CH, McCarthy GJ, Milligan KR: Implications of endotracheal tube biofilm for ventilator associated pneumonia. Intensive Care Med. 1990, 25: 1072-1076. 10.1007/s001340051014.
Adair CG, Gorman SP, O'Neill FP, McClurg B, Goldsmith EC, Webb CH: Selective decontamination of the digestive tract does not prevent the formation of microbial biofilm on endotracheal tubes. J Antimicrob Chemother. 1993, 31: 689-697. 10.1093/jac/31.5.689.
Jansen B: New concepts in the prevention of polymer-associated foreign body infections. Zentralbl Bakteriol. 1990, 272: 401-410.
Slee AM, O'Connor JR: In vitro antiplaque activitiy of octenidine dihydrochloride (WIN 4146-2) against preformed plaques of selected oral plaque forming microorganisms. Antimicrob Agents Chemother. 1983, 23: 379-384.
Inglis TJ, Millar MR, Jones JG, Robinson DA: Tracheal tube biofilm as a source of bacterial colonization of the lung. J Clin Microbiol. 1989, 27: 2014-2018.
Olson ME, Harmon BG, Kollef MH: Silver-coated endotracheal tubes associated with reduced bacterial burden in the lungs of mechanically ventilated dogs. Chest. 2002, 121: 863-870. 10.1378/chest.121.3.863.
Harke HP: Octenidinedihydrochloride, properties of a new antimicrobial active agents. Zentralbl Hyg Umweltmed. 1989, 188: 88-93.
Kramer A, Assadian O, Müller G, Reichwagen S, Widulle H, Heldt P, Nürnberg W, (eds): Octenidine-dihydrochloride, Chlorhexidine, Iodine and Iodophores. 2008, Stuttgart: Georg Thieme Verlag
Underwood MA, Pirwitz S: APIC guidelines committee: Using science to guide practice. Am J Infect Control. 1999, 27: 141-144. 10.1016/S0196-6553(99)70090-8.
Sedlock DM, Bailey DM: Microbicidal activity of octenidine hydrochloride, a new alkanediylbis[pyridine] germicidal agent. Antimicrob Agents Chemother. 1985, 28: 786-790.
Bailey DM, De Grazia CG, Hoff SJ, Schulenberg PL, O'Connor JR, Paris DA, Slee AM: Bispyridinamines: a new class of topical antimicrobial agents as inhibitors of dental plaque. J Med Chem. 1984, 27: 1457-1464. 10.1021/jm00377a014.
Rello J, Kollef MH, Diaz E, Sandiumenge A, del Castillo Y, Corbella X, Zachskorn R: Reduced burden of bacterial airway colonization with a novel silver-coated endotracheal tube in a randomised multiple-centre feasibility study. Crit Care Med. 2006, 34: 2766-2772. 10.1097/01.CCM.0000242154.49632.B0.
We are much obliged to Heimomed for granting the article-processing charge and for supplying the coated and uncoated tracheotomy tubes.
MZ performed the experiments, analysed and interpreted the data, as well as drafted and wrote the manuscript. ML participated in performing the experiments. MS participated in the study design and supervised the experiments. OA and BS had the idea for the study, participated in the study design and performed statistical analysis and analysed and interpreted the results. All authors have been involved in drafting the manuscript or revising it critically for important intellectual content and have read and approved the final manuscript.
Electronic supplementary material
Additional file 1: Overview of bacterial colonization on coated versus uncoated tracheotomy tubes. The table illustrate the bacterial colonization on all 16 polymer tracheotomy tubes after contamination with S. aureus or P. aeruginosa at different experimental time points (T1, T2, and T3). (XLS 30 KB)
About this article
Cite this article
Zumtobel, M., Assadian, O., Leonhard, M. et al. The antimicrobial effect of Octenidine-dihydrochloride coated polymer tracheotomy tubes on Staphylococcus aureus and Pseudomonas aeruginosa colonisation. BMC Microbiol 9, 150 (2009) doi:10.1186/1471-2180-9-150
- Antimicrobial Effect
- Tracheotomy Tube
- Bacterial Burden
- Mucous Skin
- Antimicrobial Coating